DAP INC -- 52409, DERUSTO AEROSOL RUST PREVENTIVE (SUPDAT) -- 8010-00N050380 
=====================  Product Identification  =====================

Product ID:52409, DERUSTO AEROSOL RUST PREVENTIVE (SUPDAT)
MSDS Date:07/15/1992
FSC:8010
NIIN:00N050380
=== Responsible Party ===
Company Name:DAP INC
Box:277
City:DAYTON
State:OH
ZIP:45401-0277
Country:US
Info Phone Num:800-543-3840
Emergency Phone Num:800-543-3840;513-667-4461
CAGE:90300
=== Contractor Identification ===
Company Name:DAP INC.
Box:277
City:DAYTON
State:OH
ZIP:45401-0277
Country:US
Phone:513-253-7154/800-543-3840
CAGE:90300

=============  Composition/Information on Ingredients  =============

Ingred Name:ACETONE  (SARA III)
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 25-30%
OSHA PEL:1000PPM
ACGIH TLV:750PPM/1000 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15-20%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT

Ingred Name:BUTANE
CAS:106-97-8
RTECS #:EJ4200000
Fraction by Wt: 10-15%
OSHA PEL:800 PPM
ACGIH TLV:800 PPM

Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED; (MINERAL SPIRITS)
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 5-15%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM

Ingred Name:STODDARD SOLVENT
CAS:8052-41-3
RTECS #:WJ8925000
Fraction by Wt: 1-5%
OSHA PEL:500 PPM
ACGIH TLV:100 PPM

Ingred Name:TOLUENE  (SARA III)
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 3-15%
OSHA PEL:200 PPM/150 STEL
ACGIH TLV:50 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:VOLATILE ORGANIC COMPOUNDS:(GRAMS/LITER):540-623
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:VOLATILE ORGANIC COMPOUNDS. VOC MATERIAL
    (GRAMS/LITER):540-623.
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:VENT:LOW AREAS. CHECK ALL LOW AREAS (BASEMENTS, SUMPS,
    ETC.) FOR VAPOR BEFORE ENTERING.
RTECS #:9999999ZZ
OSHA PEL:N/K 
ACGIH TLV:N/K 

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MAY IRRITATE EYES, SKIN, NOSE &
    RESP TRACT. HARMFUL IF INHALED. HARMFUL/FATAL IF SWALLOWED. IF
    INGESTED, THIS PROD MAY CAUSE VOMIT, DIARR, & DEPRESSED RESP. ASPIR
    OF MATL INTO LUNGS DUE TO VOMIT  MAY CAUSE CHEM PNEUMONITITS WHICH
    CAN BE FATAL. INHALATION MAY CAUSE AFFECT BRAIN/NERV SYS CAUSING
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:HDCH, DIZZ OR NAUS. CHRONIC:RPTS HAVE
    ASSOC PERM BRAIN & NERV SYS DMG W/PRLNGD & RPTD OCCUP OVEREXP TO
    SOLV. PRLNGD/RPTED CONT W/SKIN CAN CAUSE DEFAT OF SKIN WHICH MAY
    LEAD TO DERM. OVEREXP/M ISUSE OF TOLUENE CAN CAUSE LIVER, KIDNEY, &
    BRAIN DMG, AS WELL AD CARDIAC ABNORMALITIES. NOTE:TOLUENE APPEARS
    (SUPDAT)
Medical Cond Aggravated by Exposure:NONE KNOWN.

=======================  First Aid Measures  =======================

First Aid:EYE:FLUSH W/LG AMTS OF WATER FOR AT LEAST 15 MINS. CONT PHYS
    IMMED. SKIN:WASH IMMED W/SOAP AND WATER. INHAL:REMOVE TO FRESH AIR.
    CONT PHYS IMMED. INGEST:DO NOT INDUCE VOMIT. IMMED CONT PHYS OR
    REGIONA L POIS CTL CTR FOR ADDITIONAL TREATMENT.

=====================  Fire Fighting Measures  =====================

Flash Point:SUPDAT
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT . COOL EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CNTNRS MAY EXPLODE IF EXPOSED TO EXTREME
    HEAT. ELIM SOURCE OF IGNIT, HEAT, ELEC EQUIP, SPARKS & OPEN FLAMES.
    DO NOT PUT IN CONT W/OXIDIZING/CAUSTIC MATLS.

==================  Accidental Release Measures  ==================

Spill Release Procedures:DIKE SPILL AREA. USE ABSORBENT MATL OR SCRAPE
    UP DRIED MATL AND PLACE INTO CONTAINERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AWAY FROM CAUSTICS AND
    OXIDIZERS. KEEP CNTNRS TIGHTLY CLSD WHEN NOT IN USE. KEEP
    CONTAINERS FROM EXCESSIVE HEAT AND FREEZING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT STORE AT TEMPS
    ABOVE 120F. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING &
    INHALING VAPORS MAY BE HARMFUL OR FATAL.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF 8-HOUR EXPOS LIM/VALUE IS EXCEEDED FOR ANY
    COMPONENT, USE NIOSH/MSHA APPRVD RESP. CONSULT SFTY EQUIP SUPPLIER
    & OSHA REG, 29 CFR 1910.134 FOR RESPIRATOR REQUIREMENTS.
Ventilation:SUFFICIENT MECH VENT (LOCAL/GEN EXHAUST) TO MAINTAIN EXPOS
    BELOW PEL & TLV. VAPS ARE HVR/AIR & WILL COLLECT IN (SUPDAT)
Protective Gloves:SOLVENT IMPERVIOUS GLOVES.
Eye Protection:ANSI APPVD GOGG/SFTY GLSSES(OTR PROT EQT
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. EYE PROT:
    W/SIDESHIELDS .
Work Hygienic Practices:WASH CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
MFR TRADE NAME/PART #:ENAMEL SPRAY, 888 GLOSS BRIGHT YELLOW. SPEC
    GRAV:0.66-1.04 (H*20=1). FL PT:AEROSOL (EXTREMELY FLAMM). EFTS OF
    OVEREXP:ON NAVY LISTING OF OCCUP CHEM REPRO HAZ. SEEK CONSULTATION
    F ROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST INFO &
    SAFE HNDLG & EXPOS INFO . VENT:LOW AREAS. (ING 9)

==================  Physical/Chemical Properties  ==================

Vapor Density:>1
Spec Gravity:SUPDAT
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:OPAQUE LIQUID, VARIOUS COLORES, GASOLINE-LIKE ODOR
Percent Volatiles by Volume:85-90

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS AND CAUSTICS.
Stability Condition to Avoid:EXCESSIVE HEAT AND FREEZING.
Hazardous Decomposition Products:NORMAL COMBUSTION PRODUCTS, I.E. CO*X,
    NO*X.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF ACCORDING TO FEDERAL, STATE, AND
    LOCAL STANDARDS. USE ALL MATL BEFORE DISP. IF UNABLE TO USE ENTIRE
    CONTENTS OF CAN, RELIEVE PRESSURE IN CONTAINER UNTIL IT EQUALS
    EXTERNAL PRESSURE.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.